2026-04-09Views：
general domestic machine a barrel of about 800. Air filter oil filter size is not the same. Prices vary.
Many customers will ask about the maintenance of the screw air compressor when purchasing the screw air compressor. They will care about how much the screw air compressor costs and how much the maintenance costs. Then we will make a unified reply to this question:
after the newly bought screw air compressor is used for a period of time, it is necessary to carry out routine maintenance. Maintenance is divided into minor maintenance and major maintenance. Minor maintenance only needs to replace the air compressor oil and oil filter, which is usually replaced after the new machine runs for 500 hours. In addition to replacing these two kinds of major maintenance, the air compressor air filter element, oil and gas separator core, motor grease, etc. This maintenance is carried out about 3000 hours after the machine operation, specific depends on the working environment, the environment is very dirty, such as a lot of dust, it is necessary to shorten this time.
Air compressor maintenance is to make the machine can better run in a better state. Just like car maintenance, if the maintenance is good, the machine failure rate will be greatly reduced, which not only saves the time and effort caused by frequent maintenance, but also prolongs the service life of the air compressor. Therefore, the maintenance of the air compressor must be done well at ordinary times, and do not loathe to give up the maintenance money. Otherwise, when the carbon deposit of the main engine bites this kind of fault, it will cost a lot.
To answer this question, it depends on what brand you buy, how big cubic screw air compressor, the smaller the machine, the lower the maintenance cost, on the contrary, the cost is large; domestic brand screw air compressor maintenance costs relative to imported brand air compressor, maintenance prices are also much more affordable. Therefore, before you buy a screw air compressor, you must understand these contents and know fairly well. After all, the use cost is the large cost of the air compressor running for several years and the proportion of more than ten years.
Which is better, oil-free or oil-free air compressor-comparative analysis of water-lubricated air compressor and oil-injected air compressor of Shanghai granklin group in the air compressor market, oil-free air compressor and oil-injected air compressor are two common types. They each have advantages
Gas compressors play an important role in many fields. They are widely used in industrial production to provide power or compressed gas for various processes. Whether it is manufacturing, chemical industry, or oil and gas industry, gas compression
It is feasible to install two air compressors in one pipeline. This configuration is usually divided into parallel and series modes. Purpose of 1. parallel mode: to increase gas flow. Note: synchronous operation: to ensure that the two compressors run synchronously, which is related to control
In the highly sophisticated field of chip packaging, compressed air is an indispensable role! However, the compressed air here is not of any quality, especially for its oil content, which has strict requirements! Imagine that,
In industrial production, in order to meet the large-scale gas demand or improve the reliability of the system, two or more air compression systems are often used in parallel operation. The core principle is to achieve multiple devices to work together through intelligent control, the following from the technical logic, control strategy and energy efficiency.
The air compressor can operate without opening the air dryer, but long-term or specific operating conditions may cause equipment failure, reduce production efficiency, and increase maintenance costs. The following analysis is based on three dimensions: technical principles, potential risks, and applicable scenarios: 1. techniques
The cooling range of the compressed air after treatment of the cold dryer (freeze dryer) mainly depends on the dew point target of the equipment design and the initial intake air temperature. Usually, the compressed air temperature can be reduced to a level close to or slightly higher than the ambient temperature. The specific analysis is as follows: 1. the cold dryer
With the wide application of screw air compressor and the increasing demand of the market, oil-free screw air compressor has become more and more popular in the market in recent years. There are also many customers who will ask questions about oil-free screw air compressors. Today, the editor is simple with everyone.
In the production of aseptic drugs, all oil-free air compressors should be selected, especially those certified by ISO 8573-1 Class 0, such as oil-free scroll air compressors or water-lubricated oil-free screw air compressors. The following is a detailed analysis of this option: 1. sterile drug production is empty.
The oil content standards of hospital air compressors must strictly follow the medical industry standards to ensure that compressed air does not pollute medical equipment, medicines or the operating environment. The following are specific standards and implementation points: 1. oil content standard standard source oil content requirements
2018 Granklin Group. All rights reserved 沪ICP备18000439号-2
