Large maintenance time of air compressor host

Maintenance knowledge one:

minor maintenance only needs to replace the air compressor oil and oil filter, which is usually replaced after 500 hours of operation of the new machine. Major maintenance is carried out about 3000 hours of operation of the machine, and the air filter element of the air compressor, oil and gas separator core, motor grease, etc.

Maintenance knowledge two:

generally, the first maintenance of a new machine is 500 hours, and the second maintenance is about 2000 hours, which can be determined by the specific use environment. Time is not fixed, but if the environment is too bad, it is best to maintain it in advance. If the environment is good, it can be slightly delayed.

Maintenance knowledge three:

the first maintenance is for the machine to run for 500 hours, followed by no maintenance for 2000-3000 hours. Replace the three filters (air filter, oil filter, oil and gas separator) and oil!

Maintenance knowledge four:

air compressor daily maintenance]

1. After the new machine is used for 500 hours, the oil grid and the special oil for the screw machine need to be replaced;

2. Replace maintenance consumables every 2000 hours: oil and gas separator, oil grid, style and oil.

3. Pay attention to the belt tightness, oil level, display status on the display panel, check temperature, noise, etc.

4. The machine should choose a place with good ventilation, sufficient light, dry, clean air and less dust.

5. After the machine has been running for a period of time, check the safety valve, thermostat, solenoid valve, radiator and other accessories that are easy to cause the machine to malfunction, and register and deal with it in time.

Maintenance knowledge five:

how often is the air compressor maintained? This screw air compressor is generally maintained according to the following conditions

after the newly bought screw air compressor is used for a period of time, it is necessary to carry out routine maintenance. Maintenance is divided into minor maintenance and major maintenance. Minor maintenance only needs to replace the air compressor oil and oil filter, which is usually replaced after the new machine runs for 500 hours. In addition to replacing these two kinds of major maintenance, the air compressor air filter element, oil and gas separator core, motor grease, etc. This maintenance is carried out about 3000 hours after the machine operation, specific depends on the working environment, the environment is very dirty, such as a lot of dust, it is necessary to shorten this time.

Air compressor maintenance is to make the machine can better run in the best condition. Just like car maintenance, if the maintenance is good, the machine failure rate will be greatly reduced, which not only saves the time and effort caused by frequent maintenance, but also prolongs the service life of the air compressor. Therefore, the maintenance of the air compressor must be done well at ordinary times, and do not loathe to give up the maintenance money. Otherwise, when the carbon deposit of the main engine bites this kind of fault, it will cost a lot.

To answer this question, it depends on what brand you buy, how big cubic screw air compressor, the smaller the machine, the lower the maintenance cost, on the contrary, the cost is large; domestic brand screw air compressor maintenance costs relative to imported brand air compressor, maintenance prices are also much more affordable. Therefore, before you buy a screw air compressor, you must understand these contents and know fairly well. After all, the use cost is the large cost of the air compressor running for several years and the proportion of more than ten years.